Product ID:PENETRANT REMOVER H91A
MSDS Date:08/30/1994
FSC:6850
NIIN:01-268-6717
MSDS Number: BVHKJ

CHEM-TREND INC

3205 E GRAND RIVER
HOWELL, MI 48843-8552
US

Emergency Phone: 517-546-4520

Info Phone: 517-546-4520

Preparer: JLG

Cage: 2W738

DUNN R G ASSOCIATES INC

HUMBLE, TX 77396-2078 US

Telephone: 281-441-7772

Cage: 0A272

DIETHYLENE GLYCOL MONOBUTYL ETHER

CAS: 112-34-5

RTECS: KJ9100000

Fraction By Weight: 45-55%

NON-IONIC DETERGENTS - DESCRIBED BY MFR AS NON-HAZARDOUS AS

Fraction By Weight: 45-55%

IMIDAZOLINE, SUBSTITUTED

Fraction By Weight: <5%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN:PROLONGED/REPEATED SKIN CONTACT
CAUSES IRRITATION, DERMATITIS. HARMFUL AMOUNT MAY BE ABSORBED
THROUGH THE SKIN. EYE:WILL IRRITATE. INGESTED:MAY BE ASPIRATED INTO
LUNGS DURING VOMITING. CHRONIC:EX CESSIVE EXPOSURE MAY CAUSE LIVER,
KIDNEY AND BLOOD EFFECTS.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO COMMENTS OTHER THAN
THE ABOVE REFERENCES TO THE THREE LISTINGS.
Effects of Overexposure:SKIN:IRRITATION, DERMATITIS. HARMFUL AMOUNT MAY
BE ABSORBED. EYE:IRRITATION. INGESTED:MAY BE ASPIRATED INTO LUNGS
DURING VOMITING. INHALED:NAUSEA, DIZZINESS, IRRITATION. AVOID
BREATHING VAPOR OR SPRA Y.
Medical Cond Aggravated by Exposure:GET IMMEDIATE MEDICAL ATTENTION

First Aid:IF IRRITATION PERSISTS OR IS SEVERE, SEE A DOCTOR. EYE:FLUSH
W/WATER 15 MIN, SEE A DOCTOR. SKIN:WASH WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. INHALED:IF ADVERSE
EFFEC TS SUCH AS DIZZINESS, NAUSEA OR IRRITATION ARE NOTED, REMOVE
TO FRESH AIR. CONTACT PHYSICIAN. INGESTED:IF PRODUCT IS SWALLOWED,
DO NOT INDUCE VOMITING. CONTACT A PHYSICIAN IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:>212F,>100C
Lower Limits:0.9
Upper Limits:24.6
Extinguishing Media:USE FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIRE FIGHTING IN A CONFINED SPACE.
Unusual Fire/Explosion Hazard:"NONE KNOWN"

Spill Release Procedures:SMALL:SOAK UP W/ABSORBENT MATERIAL. ELIMINATE
SOURCES OF IGNITION. VAPORS ARE HEAVIER THAN AIR & MAY SPREAD
DISTANCESOR COLLECT IN LOW AREAS. DIKE AREA TO PREVENT RUNOFF,
RECOVER LIQUID, SOAK UP REMAI NING LIQUID WITH ABSORBENT MATERIAL.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON MSDS.

Handling and Storage Precautions:KEEP DRUMS AND CONTAINERS OF PRODUCT
CLOSED WHEN NOT IN USE. DO NOT HANDLE OR STORE NEAR HEAT OR FLAMES.
DO NOT ADD ANY OTHER ADDITIVE INGREDIENTS.
Other Precautions:WHEN NORMAL NON-DESTRUCTIVE TESTING APPLICATION
PRACTICES ARE EMPOLYED AT AMBIENT TEMPERATURES, WE DO NOT
ANTICIPATE EXCESSIVE EXPOSURE LIMITS TO BE EXCEEDED.

Respiratory Protection:USE RESPIRATOR WHEN ENGINEERING CONTROLS FAIL OR
NEED TO BE SUPPLEMENTED. WHEN NEEDED USE ONLY MSHA/NIOSH APPROVED
AIR- SUPPLIED RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR.
Ventilation:GOOD INDUSTRIAL HYGIENE PRACTICE RECOMMENDS THAT
ENGINEERING CONTROLS BE USED TO REDUCE CONCENTRATIONS BELOW THE
PEL.
Protective Gloves:IMPERVIOUS (NEOPRENE, PVA, NBR, NITRILE)
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS OR GOGGLES
Other Protective Equipment:APPROPRIATE CLOTHING TO AVOID SKIN CONTACT.
Work Hygienic Practices:MFR: ? HMIS:USE STRICT CHEMICAL HYGIENE
PRACTICE. AVOID UNNECESSARY EXPOSURE. WASH THOROUGHLY BEFORE EATING
OR DRINKING.
Supplemental Safety and Health
NONE

HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>446F,>230C
Vapor Pres:1 MM
Vapor Density:>1
Spec Gravity:0.98
Evaporation Rate & Reference:<1 (N-BUAC=1)
Solubility in Water:MISCIBLE
Appearance and Odor:RED LIQUID,SLIGHT FRUITY ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:"NONE KNOWN"
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. THIS PRODUCT DOES NOT FALL UNDER CURRENT EPA RCRA
DEFINITIONS OF HAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.